Date:
MSDS No.:
5/19/2008
CAN-CW42
Trade Name:
Sizes:
Innershield NR-212
All
5/19/05
Supersedes:
M A T E R I A L S A F E T Y D A T A S H E E T
For Welding Consumables and Related Products
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
Product Type:
Representative Classifications:
Flux Cored Electrode
AWS E71TG-G
E71TG-G-H16
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
Section III - Hazardous Ingredients (1)
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1)
The term “hazardous” in “Hazardous Ingredients” should be interpreted as a term required and defined in the Hazardous Products Act and
does not necessarily imply the existence of any hazard.
TLV
LD50
LC50 mg/m3
Ingredients:
CAS No. Wt. % mg/m3 (Route/Species) (Route/Species)
Iron
7439-89-6
513-77-9
1-5
1-5
10*
****
10
Not Available
11 mg/kg LDLo
(oral/human)
Not Available
Not Available
Barium compounds (as Ba)
Aluminum and/or aluminum alloys (as Al)
Manganese and/or manganese alloys and compounds (as Mn)
Strontium compounds (as Sr)
Magnesium and/or magnesium alloys and compounds (as Mg)
Fluorides (as F)
7429-90-5
7439-96-5
1633-05-2
7439-95-4
7789-75-5
7440-02-0
1332-58-7
7440-21-3
12004-83-0
554-13-2
1-5
Not Available
9 g/kg
(oral/rat)
Not Available
2.3 LCLo
(inhalation/human)
1-5
0.2
1-5
10*
10*
2.5
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
230 mg/kg LDLo
(oral/dog)
4250 mg/kg
1-5
1-5
(oral/rat)
50 mg/kg LDLo
(intravenous/mouse)
590 g/kg LDLo
(oral/rat) reproductive
Nickel (metal)
1-5
1.5
Mineral silicates
1-5
5**
10*
5
Silicon and/or silicon alloys and compounds (as Si)
Zirconium alloys and compounds (as Zr)
Lithium compounds (as Li)
0.1-1
0.1-1
0.1-1
Not Available
Not Available
4111 mg/kg LDLo
(oral/human)
10*
Carbon steel tube
10*
7439-89-6
60-100
Not Available
Not Available
Notes:
(LDLo, LCLo) Lowest published toxic
concentration.
(*)
Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(****)
There is no listed value for insoluble barium compounds.
The TLV for soluble barium compounds is 0.5 mg/m3.
(**)
As respirable dust.
Section IV - Physical Data
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable
to this product and its use.
Section V - Hazard Data
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 9/07
(CONTINUED ON SIDE TWO)
|